|
GENERAL MAINTENANCE
Origional Author: Ted Rose (tr@fourfold.ocunix.on.ca)
Below is a listing of various parts and part numbers that are generally required when you undertake general maintenance or a tune-up of your aluminium friend. This is just a partial guide to help you order parts from a local automotive store if you do not wish to go a longer distance for parts (See Section 9 in this FAQ) Because of the age of some of our Land Rovers, and the fact that many have had parts interchanged over their lives, it's difficult to give exact listing for everyone. Yours might be a little different. If in doubt, take the parts with you to the store or bring it with you Tune-Up Day and we will help figure it out. More complete sources for part numbers are available. The Land Rover Factory Parts Manual is the ideal source for information. Check with fellow Land Rover owners. Some of them are fanatics and may have a copy of this tome.
Four season coolant with rust inhibitors. Flush the system first. If an "O" ring gasket is required, the rear hub seal from a 1961 - 76 Austin Mini makes a good replacement.
-
Thermostat:
All models use a 160 degrees Farenheit unit.
Parts: Land Rover 74c 532453
82c 596225
Gates 33006
Stant 336-160
-
Engine Oil:
- "Tight" engines with less than 50,000 miles: 10w40
- "worn" engines with more than 50,000 miles: 20w50
-
Transmission-Differential: 90 EP Hypoid gear oil
-
Swivel Ball & Steering Box: 140 EP Hypoid gear oil
-
Fairey Overdrive:. . . . . . . . . 50 EP Hypoid gear oil (Superwinch bought Fairey and the Superwinch manual claims 90 EP Hypoid gear oil)
-
Remove and clean glass sediment bowl. If none, replace with an in-line filter between tank and engine/carb. Filters are available at any auto parts store. Same size as fuel line.
-
Hub seals:
Front and rear, double lipped seals for all models.
Parts: Land Rover
National: 410694
-
U-joints:
A bad U-joint can ruin the differential and gearbox bearings. Grease if they are of the type that have a grease nipple.
Parts:
Land Rover 2 15/16" from cap top to cap top RTC3291
3 7/32" from cap top to cap top RTC3346
Precision 1948-62 344
1963-76 369
Spicer 1954-59 5-4x
1969-71 5-153x
-
Oil Filter
Parts:
Land Rover: 2.0l RTC3183
2.25l RTC3185 (long 6-13/16")
RTC3184 (short 4-5/8")
2.6l RTC3183 (6 cylinder)
Series I Series II & IIA
From suffix "B"
no. 25143369-C
- Fram CH-853pl - Fram CH-834pl
- Wipac OF-671 - Hastings P-186
- Kralinator L-891 - Kralinator L-532
Series II & IIA Series III
From suffix "D"
no. 27108243D
- Fram CH-822pl - Fram CH-834pl
- Hastings P-186
- Kralinator L-535 - Kralinator L-532
6 Cylinder
- Fram CH-853pl
- Wipac OF-671
- Kralinator L-891
-
ELECTRICS:
- ALTERNATOR
- Lucas . . . 37 amp . . . 16ACR
- Lucas . . . 45 amp . . . LRA 103
- COIL
- Lucas . . . all negative earth . . . HA12
- DISTRIBUTOR:
The Distributor used on Series II, IIA, and early III and Rovers is the same as found on the 1960's Austin Mini and numerous other British cars. It is a LUCAS 25D4. In the early-mid 1970's this was changed to the LUCAS 45D4 distributor. The 6 cylinder Land Rover used a Lucas 25D6 distributor.
Knowing this, if you can't get your distributor cap for your 1964 Land Rover using the Land Rover part number, just ask for the distributor cap off of a 1968 Austin Mini. It will fit.
-
Points:
Lucas 25D4 TK-50
" 45D4 (cs-8) 54423769
Land Rover 2.25l petrol 1956-74 RTC3270
" " Lucas new type (red) RTC364
" " (blue) RTC6627
" " Military 24v FFR RTC6622
" " Duceellier type RTC6625
" " 6 cyl RTC3270
Blue Streak LU-1617XP (for 25D4)
LU-1685 (for 45D4)
Borg & Beck A-527
Echlin CS-207a (for 25D4)
Niehoff WA-106
Delco E-109
-
Condensor:
Lucas 45D4 54429551
Land Rover 2.25l petrol 1956-77 RTC3472
" " Lucas new type RTC6621
" " Military 24v FFR 600730
" " Duceellier type RTC6620
" " 6 cylinder RTC3472
Blue Streak LU-206 (for 25D4)
LU-207 (for 45D4)
Echlin EP-29 (for 25D4)
Filko 6 cylinder LU-65
Niehoff WA-226
Delco E-211
-
Rotor:
Lucas 25D4 RA-1
" 45D4 54422803
Land Rover 2.25l petrol to -1976 RTC3612
" " Lucas new type RTC3614
" " Military 24v FFR RTC6628
" " Duceellier type RTC4933
" " 6 cyl RTC4542
Blue Streak 4 cylinder LU-300 (for 25D4)
LU-320 (for 45D4)
6 cylinder LU-302
Echlin 4 cylinder EP-41 (for 25D4)
6 cylinder EP-44
Niehoff 4 cylinder WA-300
6 cylinder WA-313
Delco 4 cylinder E-407
6 cylinder E-302
-
Cap:
Lucas 25D4 DC-6
" 45D4 (dc-8) 54427109
Land Rover 2.25l II, IIA Screw type 600328
" " IIA, III early push-in 566859
" " New type push-in RTC3278
" " Military 24v FFR 90600725
" " Duceellier type RTC4932
" " 6 cyl 539570
Blue Streak 4 cylinder LU-421 (push in--25D4)
LU-422 (screw in--25D4)
LU-420 (horizontal--25D4))
LU-430 (45D4)
6 cylinder LU-429
CEW 4 cylinder 6008302
Echlin 4 cylinder EP-48 (push in--25D4)
EP-38 (screw in--25D4)
EP40 (horizontal--25D4)
6 cylinder EP-55
Niehoff 4 cylinder WA-412
6 cylinder ----
Delco 4 cylinder L-307
6 cylinder L-310
-
GENERATOR
- Brushes:
- Lucas . . . . . . . . BS3-227541
- Land Rover . . . RTC3255
-
GLOW PLUGS
- Land Rover . . . 568335
- Champion . . . . . AG45
- KLG . . . . . . . . GF210/t
-
SPARK PLUGS
Parts: SI SII & IIA SIII 6-cyl
from "B" from "D"
Land Rover RTC3569 RTC3570 RTC3571
Bosch WR7DS (silver)
" WR8DP (platinum)
Champion N-5 N-5 N-9Y N-12Y N-5
AC 44XL 44XL 42LXS 44XLS 44XL
Autolile 2616 2616 52 3205 2616
- for radio interference supression, get "R" designator
-
STARTER
- Lucas
- Ser III petrol . . . . . . . . .M418G
- Ser III diesel . . . . . . . . . . M45G
- Land Rover
- petrol . . . . . . . . . . . .RTC5225E
- diesel . . . . . . . . . . . . RTC5232E
-
SOLENOID
- Lucas
- Petrol . . . . . . . . . . . . . 76766
- Ser IIA diesel . . . . . . 76727E
- Ser III diesel . . . . . . . 76803
-
VOLTAGE REGULATOR
- Lucas
- 4 cylinder w/alt . . . . . RB340
- 6 cylinder . . . . . . . . . . .37565
- Ford Tractor
- 6 cylinder . . . . . . . . . . .DONN10505A
|
|
|
Copyright Dixon Kenner, 1995-2011. Last modified March 15, 2005.
Comments? Send mail to Dixon Kenner or Benjamin
Smith Site Designed and Created by Bill Maloney |
|